RV Park Reviews

Welcome Guest ( Log In | Register )

> Generator Advice Needed
post Oct 12 2012, 07:58 PM
Post #1


Group: Moderated
Posts: 2
Joined: 19-June 08
Member No.: 22531

Hi all, I need some advice on a generator issue. I have an Onan Marquis Gold 5.5. It is having trouble running properly when placed under a load (AC, Water Heater, etc.). The problem never existed until recently. When placing a load on it, it would start to act like it wants to stall, RPM's go down, sputters, backfires, then seems to recover. After a couple of minutes, or sometimes sooner, it will do it again. Seems to clear up after it is running for awhile and is hot. Then another problem popped up with the thing not starting at all. I ended up replacing the carb and it starts right up, but the original running under a load problem is back. It was then suggested I was having a fuel pump problem, replaced that today to no avail. Has anyone experienced a similar problem with this model generator? I hate to keep throwing money at it and not having the problem solved. I am wondering if I just don't have a set of bad plugs? Again, it appears the problem goes away if it has run for quite sometime with no load. Any suggestions are appreciated!
User is offlineProfile CardPM
Go to the top of the page
+Quote Post
Reply to this topicStart new topic
John Blue
post Oct 13 2012, 09:14 AM
Post #2

Advanced Member

Group: Members
Posts: 2174
Joined: 9-November 03
From: Brandon, FL.
Member No.: 214

One item you need to think about is an (air leak) in the fuel line. If the fuel lines are on the old side and some tine ago were not set up to use the 10% ethanol fuel. Ethanol will eat up fuel filters and fuel lines if not the newer type. All filters and fuel lines have been changed out a couple years ago but some places may have the old stock on the shelf yet, you need to ask. The better supply house's replaced stock years ago.

We have a diesel Gen but it will work the same way as what you see. Run under no load but stall under load. Do this. Pick up a short amount of fuel line and bypass the main fuel tank. Set a 5 gal fuel can on the ground and feed the unit. If it runs under load with no problem you will need to replace the fuel line back to the fuel tank. Low cost test to run. Note: you will never see the cracks in the fuel line and no fuel will run out as point air is leaked in.

Brandon, Fl.
FMCA F-248693
Foretravel MH
Honda CRV tow
User is offlineProfile CardPM
Go to the top of the page
+Quote Post

Posts in this topic

Reply to this topicStart new topic
1 User(s) are reading this topic (1 Guests and 0 Anonymous Users)
0 Members:


Lo-Fi Version